|
|
 |
|
|
 1985-1993
Dodge Ram Truck TSB
Index
|
| TSB's
for the older series Rams are UNDER CONSTRUCTION - Progress will
be slow! |
| . |
|
1987-1993 dodge Ram truck Technical Service
Bulletins - TSB
TSB Number SUBJECT
- 02-05-87A 85-88
W, AW 4WD - Vehicle leaning or low on the left side
- 02-06-90A 90-91
AD 2WD - Front Spring Spacer for leaning trucks
- 02-09-90 89-90
AD 4WD - Service Manual Revisions For Camber Spec.
- 02-02-91 92
AD 2WD - Front Spring Spacer for leaning trucks
TSB Number SUBJECT
- 03-02-93 92-93
131" or 149" wheelbase - Launch Shudder/Vibration
TSB Number SUBJECT
- 05-07-90
89-90 Rear Wheel Anti Lock Faults Caused By Water Contamination
- 05-01-91
81-91 4X4 Rear Wheel Anti-Lock Speed Sensor Connector Repair
- 05-05-91
90-91 Front Disc Brake Noise Bendix Disc Brakes
- 05-04-92A Superseded by TSB
05-21-94
- 05-21-94 89-93
Premature brake wear with 12" linings
- 05-03-97 all
- 1999 Chassis Dynamics Diagnostics - 27 PAGES!
- If you have brake pull, check this TSB
TSB Number SUBJECT
- 06-03-86 Superseded by TSB
06-02-87
- 06-02-87 84-86
6cyl w/ manual - Clutch "Chatter", "Roaring" or "Howling" Noise
- 06-02-88 all
B D N Trucks w/ manual - Clutch installing procedure
- 06-01-89 all
up to 89 with manual trans - Clutch Splines/Pilot Bushing Lubrication
- 06-03-89 87-89
with manual transmission - Clutch Housing, Pilot Bore Runout Face Squareness
Adjustment
- 06-01-90A 89-91
with manual trans - Transmission Noise Below 1400 RPM
- 06-01-94
89-93 with manual trans - Transmission Noise Below 1400 RPM
TSB Number SUBJECT
- 07-01-89
88-89 Auto Trans - Auxiliary Oil Cooler Freeze-up
- 07-03-90
All - Recycled Engine Coolant
- 07-01-91
89-90 Diesel - Overheating or No Heat Condition
- 07-02-91
90-91 3.9L/5.2L - Thermostat Housing Gasket Coolant Leak
- 07-04-91
90-91 Diesel - Lower Radiator Hose Leakage
- 07-05-91
91 Diesel - Drive Belt Noise
- 07-01-92 92
3.9L/5.2L - Viscous Fan drive Noise
- 07-05-93 Superseded by TSB
07-03-97
- 07-03-97
89+ Information: Engine Coolant Recommendations
TSB Number SUBJECT
- 08-08-87 superseded by TSB 08-05-98
- 08-09-88 87
FM Radio Noise
- 08-03-89 88-89
without tilt wheel - Turn Signal Switch Canceling
- 08-05-89 82-89 Map
Lamp Tab Breakage
- 08-12-90 90-91
Service Procedure - Electro Mechanical Speedometers
- 08-04-91A
90-92 Map Lamp Tab Breakage
- 08-05-91
All - Trailer Tow Wiring Installation
- 08-07-91 All
- Wiring Repair Instruction Sheets
- 08-10-91
89-91 Speedometer Reading Fluctuates and/or Speed Control Disengages
- 08-11-91
91 Fuel Reads Low When Tank Is Full
- 08-17-91 92
Radio Speakers Inoperative
- 08-28-92 Superseded by TSB
08-09-93
- 08-05-93
93 diesel - White Smoke At Startup
- 08-07-93A 92-93
Diesel 4x4 - Speed Control Surge
- 08-09-93 92-93
Intermittent Speed Control Operation
- 08-58-93 Superseded by TSB
08-33-94
- 08-11-94
89-93 Do not use Brake Parts Cleaner on Electrical Connectors
- 08-19-94 93
V6 V8 - Checking Distributor Position with the DRBII/III scan tool
- 08-33-94
91-93 Fuel Gauge Inaccuracy
- 08-36-98
All - information: Y2K compliance statement
- 08-16-98
All - Installation of Radio Transmitting Equipment
- 08-06-00 89-93
Wire Splice Repairs
| GROUP 09 - ENGINE (see
also groups 14-fuel, 18-performance, and 25-emissions) |
TSB Number SUBJECT
- 09-03-87 87
3.9L, 5.2L Rear Main Bearing Upper Oil Seal Replace - Engine In Chassis
- 09-06-87
87 5.2L Low Oil Level Dipstick Readings
- 09-08-87
88 3.9L, 5.2L Tappet Noise
- 09-01-88
88 3.9L, 5.2L Tappet Noise
- 09-11-89
89 diesel with Auto Trans - Knocking Noise at Rear of Engine - Cracked Torque
Converter Drive Plate
- 09-05-90 85-90
Tappet Noise - 3.9L, 5.2L And 5.9L "LA" Engines
- 09-04-91
87-91 New Cylinder Head Cover Gasket, 3.9L, 5.2L, and 5.9L Engines
- 09-07-91
91-92 Diesel Cylinder Head Bolt Tightening Procedure
- 09-07-92
92 3.9L, 5.2L Engine Oil Leak At Distributor
- 09-08-92 92-93
V6, V8 Supplemental Service Procedure - Rocker Arm installation
- 09-09-92
92-93 V6. V8 Supplemental Service Procedure - Short Block Assembly
- 09-08-93
93 V6, V8 Service Manual Revisions - Pushrod Length
- 09-04-94 88-93
5.9L Lower Engine Tapping Noise
- 09-09-94b 89-93
3.9L. 5.2L Oil Leak Diagnosis - Rear Main Bearing Area
- 09-10-94
92-93 3.9L MPI Excessive Valvetrain or Tappet Noise
- 09-003-01 All
- Engine Oil Additives/Supplements
- 09-004-01 Diesel
Approved Oil Filters
- 10-01-89 All
1989 and earlier - New "SG" Quality Engine Oil
TSB Number SUBJECT
- 11-02-92
88-92 Rear Tailpipe Support Cracking
| GROUP 13 - FRAME & BUMPERS |
TSB Number SUBJECT
TSB Number SUBJECT
- 14-04-87 84-87
- Accelerator Pump & Bowl Vent - Adjustment
- 14-01-89
89 Diesel - Injection Pump Diagnosis Procedure
- 14-02-89 89
Insufficient Fuel Volume Due To A Ruptured Fuel Pump Supply Hose
- 14-02-90
89-90 diesel automatic - Accelerator Pedal Effort Too High
- 14-03-93 89-93
Fuel Pump and Filter Diagnosis and Service
- 14-04-93 92-93
Fuel Pump Module Service
- 14-05-93b 91-93
V6, V8 Improved Fuel Pump
- 14-15-93
89-93 Fuel Leakage From the Roll-over Valve Vent
- 14-05-94
89+ diesel models - Use of low sulfur fuel
| GROUP 16 - PROPELLER SHAFTS and U-JOINTS |
TSB Number SUBJECT
- 16-01-94 2
piece driveshaft - launch shudder when loaded
TSB Number SUBJECT
All Engines
- 18-04-92
92 No Start/Poor Engine Performance
Gasoline Engines
- 18-02-93
92-93 V6, V8 Throttle Body Idle Calibration Check
- 18-03-93A
92-93 3.9L Sag, Hesitation Or Rough idle
Diesel Engines
- 18-05-92
92 Vehicle Surging When Cruise Control is Engaged
- 18-06-92
91-92 diesel - Lack of Power, Poor Performance in Cold Temperatures
- 18-10-92A
91-93 Diesel with Auto Trans - Erratic 3-4 and/or 4-3 Shifts (hunting)
- 18-11-92 Superseded by
TSB 18-05-93
- 18-16-92A
92-93 V6, V8 - Surging, Bucking, or Intermittent Missing
- 18-11-92 91 diesel - Engine
RPM Fluctuates When Cruise Control Is Engaged
- 18-15-92 91 diesel - White
Smoke At Start-up
- 18-18-92
91-92 Poor Engine Performance, Erratic Engine and/or Transmission Operation
- 18-05-93
91-92 diesel - Poor Power / Lack of Performance
- 18-08-93
92-93 V6, V8 Engine Buck, Surge Or Noise - Oil Pump Drive Gear Wear
TSB Number SUBJECT
- 19-02-91 89-91
4X4 - Steering Wheel Off Center
- 19-03-93 89-93
Steering Column Coupler Service
TSB Number SUBJECT
- 21-12-89 89 Manual Trans
- Speedometer Gear Replacement Procedure
- 21-05-90 89-90 Auto Trans
- Replacement Of Transmission Shift Lever And Stubshifter
- 21-14-90 90 with A518 Auto
Trans - Low/Reverse Band Wear
- 21-11-91
89-91 Auto Trans - 3-4 Upshift Noise With A500 & A518 Transmission
- 21-18-92 92-93 Auto Trans
- Delayed Upshifts and Harsh Engagement Into Drive Or Reverse
- 21-23-93 92-93 Auto Trans
- Lack of 3/4 Up-shift and Deep throttle 2/4 Up-shift
- 21-39-93 89-93 Four Speed
Auto Transmission 4-3 Downshift Clunk
- 21-04-94
92-93 Transmission Shift Lever Stuck in or Blocked Out of 5th or Reverse Gear
- 21-14-94
93 Speed Sensor Oil Leakage
- 21-17-94 93 Auto Trans
- Transmission Diagnostic Reference Supplement
- 21-18-94 88-93
AD chassis cab - Automatic Transmission 4-3 Downshift Clunk
- 21-20-94 90-93
Checking Automatic Transmission Fluid Levels
- 21-09-95
92-92 AD chassis cab - Servicing the NV4500 fifth gear nut
- 21-20-95A 92-93
AD - RWD Automatic Transmission Identification Procedure
- 21-07-97 89-93
auto - Trans Cooler Rev Flush w/ Cooler Bypass Kit Installed
- 21-004-04 Superseded
by TSB 21-010-06
- 21-010-06
89-93 Automatic Transmission Fluid Usage ATF+4 (Type MS9602)
| GROUP 22 - WHEELS AND TIRES |
TSB Number SUBJECT
- 22-01-87 86-88
All - Vibration & Smooth Road Shake at 45-65 MPH
- 22-01-91A Superseded by TSB
22-02-92
- 22-02-92 89-92
Wheel Vibration On 350 Series Trucks With Flange Type Lug Nuts
- 22-05-93 93
Tire And Wheel Runout
- 22-01-97* Discussion
about radial tire runout
TSB Number SUBJECT
- 23-08-89 89 Paint Standard
Colors
- 23-24-89 90 Paint Standard
Colors
- 23-12-90 91 Paint Standard
Colors
- 23-09-91 92 Paint Standard
Colors
- 23-21-92 93 Paint Standard
Colors
- 23-63-94
1993 and Prior - Cowl Cracks
- 23-014-06
All - Windshield Wiper Blade/Element Maintenance
TSB Number SUBJECT
- 24-06-92
87-92 Heat/Air Conditioning System Changes To The Defrost Mode When Accelerating
- 24-27-93 91-93 Air Conditioner
Compressor Noise
- 24-17-94 91-93 A/C Freeze-Up
or Lack Of Cooling
- 24-01-95A 89-93
R-12 to R134a Refrigerant Adaptaion Procedure
- 24-003-03
90-04 A/C System Additives
TSB Number SUBJECT
TSB Number SUBJECT
- 605 1991-1992 Diesel Fuel Injection
Pump
Alldata Dodge Truck TSB list - provides title and TSB number only.
1966
1967
1968
1969
1970
1971
1972
1973
1974
1975
1976
1977
1978
1979
1980
1981
1982
1983
1984
1985
1986
1987
1988
1989
1990
1991
1992
1993
Note: I am constantly working to add TSB's, but progress is
very slow.
If you need to see a particular TSB, send an email to my
email address and I will
get it posted as quickly as possible. Dave
I would like to thank Bob Bergevin, Arthur Cantrall,
Barry Drodge, David Lovell, Bill Maurits, and Steve for supplying the
information for these bulletins. And a big thank you goes to Geno's
Garage for making DodgeRam.info possible.
|
This page was edited on: February 13, 2008
