DodgeRam.info > TSB's > 23-029-04

TSB 23-029-04

Front Power Window Binds

Visit Geno's Garage
for Truck accessories.		 Geno's Garage Truck Accessories

Date: August 2, 2004

Models: 2004 (DR) Ram Truck

NOTE: This bulletin applies to vehicles equipped with trailer tow mirrors, sales code GPD or GPG.

Overview:
This bulletin involves lubricating the window channel and installing a spacer under the outside mirror.

Symptom/Condition:
Vehicles equipped with trailer tow mirrors may experience the power window on the front door binding or slow to operate.

Diagnosis:
Operate the both front power windows. If a binding condition is present in either window, perform the Repair Procedure.

Parts Required:
Qty. Part No. Description
1 06100876 Washer

 

Repair Procedure: 
1.      Separate the door trim panel from the door, leaving the wiring attached.
2. Lubricate the window run channels with MOPAR Silicone Spray Lube, p/n 04318070 or equivalent.
3. Separate the outside mirror from the door, leaving the wiring attached.
4. Install the mirror with washer, p/n 06100876, positioned over the lower rear stud on the mirror (Figure 1). The washer should sit between the gasket and the body of the mirror. Tighten the nuts to 7 Nm (60 in. lbs.).
5. Install the door trim panel.
    figure 1

Policy:    Reimbursable within the provisions of the warranty.

Time Allowance:

Labor Operation No:   Description Amount
23-31-26-92 Lubricate Window Channel And Install Spacer - One Side 0.2  Hrs.

Failure Code:

XX      Service Adjustment

I would like to thank Bob Bergevin, Arthur Cantrall, Barry Drodge, David Lovell, Bill Maurits, and Steve for supplying the information for these bulletins. And a big thank you goes to Geno's Garage for making DodgeRam.info possible.
 

  Top of Page  

  DodgeRam.info Home  

 

This page was edited on: May 3, 2004